Abstract
This study investigates the combination of two waves emitted from a single-piezoelectric crystal by use of a dual-frequency generator in a sonochemical reactor. The dual-frequency configurations analyzed were the double-modulated fundamental frequency (376-376 kHz), resonant and second harmonic, termed 376D, 376R and 376H respectively. The effect of the phase shift (Φ) and the percentage of modulation between added waves were described by the total acoustic power distribution (Pt) measured inside the sonoreactor. Moreover, optimal angle alignment and modulation between dual-frequency waves for 376D, 376R and 376H cases were selected in order to evaluate the ultrasonic synergy by sonochemical reactivity in production of H2O2, in degradation rate of a model emerging pollutant ACE, and in the TOC and biodegradability evolution in the treated effluent. Phase shift and percentage of modulation had strong effect on the resulted waveform and on the sonochemical efficiency for all, harmonic and non-harmonic, dual-frequency combinations created. In the 376D case, the best reinforcement conditions are founded at 0° and 360°. In the 376H the maximum power distribution presents a 90° period. Shift phase does not determines any cyclic pattern in the total power distribution for the 376R case. The highest H2O2 production rate was observed for the 376H case followed for 376D and 376R configurations with 1.61, 1.12 and 0.58 μM/min by angle alignment in 105, 0 and 110° respectively. The highest initial degradation rate of ACE was observed for the 376D case followed for 376H and 376R with 0.56, 0.42 and 0.33 μM/min at 100% modulation. Reduced mineralization was observed in all dual-frequency configurations (8.54% for 376D and approximately 4.5% for 376R and 3756H modes). Contrasting results are observed regard to biodegradability ratio following the next sequence 376D < 376H≈376R with 0.9, 2.30 and 2.33 respectively. Relevant intensification in hydroxyl radicals production is observed by the UV-US system increasing up three folds the ACE removal and mineralization and two folds higher biodegradability of effluent in particular for 376R and 376H cases at optimal operation condition of dual-frequency signal.